How To Change Trans Filter On A 2007 Mercedes Cls 550

Even though the manufacturer may recommend, the transmission is sealed for life. It doesn't need servicing; transmission fluid and filter changes every lx,000 miles tin extend the transmission life when properly performed.

This guide provides steps required to change transmission fluid and filter on the 7-speed manual. This is a unproblematic job that you can perform in your garage. Information technology requires a few bones tools and a special connector.

Parts you volition demand

• Transmission oil 236.15, ATF 134 FE -  0019897703 (6 quarts)
  • Recommended Shell or Fuchs Europe.
• Manual filter - 2222772000
• Manual pan gasket 2202710380
• Drain plug washer  007603012102
• Overflow pipe 2222710097 (optional)
• Pan bolts 0049903512 (recommended)

Tools required

• 722.9 Transmission Fluid Adapter Filler adapter
• Fluid transfer pump
• 6mm Allen key socket
• 10mm Allen key socket
• Extension for sockets
• Universal joint (on some models)
• Flat screwdriver
• MB specific scan tool or an IR thermometer
• Oil drain pan
• Torque wrench

Before yous start

• Avoid letting fluid get in contact with your peel. Use gloves and rubber glasses.
• Manual fluid may be too warm and cause burns.
• Secure the vehicle with jack stands in addition to the jacks.
• This procedure only replaces the fluid that is in the oil pan, which is about 40% of the total capacity of the transmission fluid.

Procedure

1. Jack upward the vehicle at all iv-wheel. The vehicle needs to be level. The easiest way to do this is on a lift. Still, if you don't have access to information technology, lift both the front and rear side of the automobile on jack stands, making certain it is leveled and sits securely.
2. Depending on the model, yous will need to remove the whole splash guard or just the rear section. Yous will need an 8mm socket to remove the screws that concord the splash guard.
3. Place an oil pad directly under the drain plug located at the bottom of the manual pan. Using a 6mm Allen cardinal, loosen the drain plug located at the bottom of the transmission pan.
4. Only one portion of oil volition menstruum out, equally there is an overflow pipe above the bleed hole. After the oil stops flowing out, utilise a suitable flathead screwdriver to push the overflow pipe up, which will allow the residual of the oil to drain out.
5. Locate and remove eight bolts that hold the transmission pan in place. For this, you will demand a 10mm Allen fundamental socket and a suitable extension. Carefully lower the manual pan and motion it out of the mode. A small corporeality of oil remains in the oil pan, and then be careful equally you lot lower the oil pan. Don't tip the pan to the side.
6. Carefully pull down and remove the filter, which is integrated into a metal housing. You may demand to wiggle until it comes complimentary. The oil filter snaps in place.
7. On the transmission pan, remove the sometime gasket and the overflow pipe. Locate and remove 2 disc-shaped magnets. Thoroughly clean both magnets and the pan itself, ensuring at that place are no metal shavings. Install a new washer on the drain plug.
8. Refit magnets and overflow pipe at their previous locations and install a new pan gasket. While plumbing fixtures the gasket, make certain it sits properly.
9. Install the new oil filter by carefully pushing it into the hole on the control valve torso. Using a restriction cleaner and rugs, make clean the mating surface at the gearbox housing.
10. Raise the transmission pan in its location and bolt it down. Utilize a torque wrench to tighten the bolts to three lb-ft.
11. Make full the transfer pump with five liters of gearbox oil and build upwards the pressure. If yous are using an electric pump, connect the pump to a twelve-volt power source and insert the pickup tube in a full fluid container.
12. Place the filler adapter into the bleed plug, connect the pump hose to it, and open the valve. Let the pump do its piece of work until five quarts are in, and so close the valve.
13. Setting the correct level requires the gearbox oil to be at 45 °C, turn on the engine, and leave information technology running until the gearbox oil temperature reaches this value. Yous will need either a specific scan tool that tin access these values or use an IR thermometer for the gearbox housing temperature.
14. With transmission temperature at 45 °C, push the gearbox lever through P-R-D and back several times.
15. Become back underneath the auto, disconnect the filler adapter allow backlog fluid to bleed until only a small amount still drains out. If there is no transmission fluid draining out, add more fluid, and repeat the process every bit needed.
16. When drainage is almost over; quickly reinstall the manual drain plug, tighten it to 17 lb-ft using a torque wrench and reinstall all remaining parts.

Where is the dipstick to measure the transmission fluid level?

The vii-Speed 722.ix transmission has no dipstick tube or dipstick. The fluid level is checked using the overflow method via the oil drain commodities hole. Ever cheque the transmission fluid at the recommended temperature for the manual fluid.

Applications

Applications of the 7-speed automated transmission include:

• 2007-2010 Mercedes-Benz CLK 63 AMG Coupé
• 2005-2007 Mercedes-Benz SLK 280 Roadster
• 2005-2007 Mercedes-Benz SLK 350 Roadster
• 2005-2007 Mercedes-Benz SLK 55 AMG Roadster
• 2005-2007 Mercedes-Benz SLK 55 AMG Black Series Roadster
• 2012-2015 Mercedes-Benz SLK 200 Roadster
• 2012-2015 Mercedes-Benz SLK 250 Roadster
• 2012-2015 Mercedes-Benz SLK 250 CDI Roadster
• 2012-2015 Mercedes-Benz SLK 350 Roadster
• 2012-2015 Mercedes-Benz SLK 55 AMG Roadster
• 2003-2006 Mercedes-Benz SL 500 Roadster
• 2006-2008 Mercedes-Benz SL 350 Roadster
• 2006-2008 Mercedes-Benz SL 550 Roadster
• 2008-2009 Mercedes-Benz SL 280 Roadster
• 2008-2011 Mercedes-Benz SL 350 Roadster
• 2008-2011 Mercedes-Benz SL 550 Roadster
• 2008-2011 Mercedes-Benz SL 63 AMG Roadster
• 2009-2011 Mercedes-Benz SL 300 Roadster
• 2012-2014 Mercedes-Benz SL 350 Roadster
• 2012-2015 Mercedes-Benz SL 400 Roadster
• 2012-2015 Mercedes-Benz SL 500 Roadster
• 2012-2014 Mercedes-Benz SL 63 AMG Roadster
• 2012-2018 Mercedes-Benz SL 65 AMG Roadster
• 2016-present Mercedes-Benz SL 400 Roadster
• 2016-nowadays Mercedes-Benz SL 500 Roadster
• 2006-2010 Mercedes-Benz R 320 CDI 4MATIC LWB
• 2006-2010 Mercedes-Benz R 350 4MATIC LWB
• 2006-2007 Mercedes-Benz R 500 4MATIC LWB
• 2007 Mercedes-Benz R 63 AMG 4MATIC LWB
• 2008-2010 Mercedes-Benz R 280 LWB
• 2008-2010 Mercedes-Benz R 280 CDI LWB
• 2008-2010 Mercedes-Benz R 350 LWB
• 2008-2010 Mercedes-Benz R 500 4MATIC LWB
• 2005-2008 Mercedes-Benz ML 280 CDI 4MATIC SUV
• 2005-2008 Mercedes-Benz ML 320 CDI 4MATIC SUV
• 2005-2008 Mercedes-Benz ML 350 4MATIC SUV
• 2005-2007 Mercedes-Benz ML 500 4MATIC SUV
• 2006-2008 Mercedes-Benz ML 420 CDI 4MATIC SUV
• 2006-2008 Mercedes-Benz ML 63 AMG 4MATIC SUV
• 2008 Mercedes-Benz ML 500 4MATIC SUV
• 2005-2007 Mercedes-Benz C 320 CDI Sedan
• 2006-2007 Mercedes-Benz C 230 Sedan
• 2006-2007 Mercedes-Benz C 280 Sedan
• 2006-2007 Mercedes-Benz C 350 Sedan
• 2004-2006 Mercedes-Benz CLS 350 four-Door Coupé
• 2004-2006 Mercedes-Benz CLS 500 four-Door Coupé
• 2005-2006 Mercedes-Benz CLS 320 CDI 4-Door Coupé
• 2006-2010 Mercedes-Benz CLS 320 CDI 4-Door Coupé
• 2006-2010 Mercedes-Benz CLS 350 4-Door Coupé
• 2006-2010 Mercedes-Benz CLS 350 CGI 4-Door Coupé
• 2006-2010 Mercedes-Benz CLS 500 4-Door Coupé
• 2006-2010 Mercedes-Benz CLS 63 AMG 4-Door Coupé
• 2007-2010 Mercedes-Benz CLS 63 AMG Black Serial iv-Door Coupé
• 2006-2010 Mercedes-Benz R 280 CDI 4MATIC Sedan
• 2006-2010 Mercedes-Benz R 320 CDI 4MATIC Sedan
• 2006-2010 Mercedes-Benz R 350 4MATIC Sedan
• 2006-2007 Mercedes-Benz R 500 4MATIC Sedan
• 2007 Mercedes-Benz R 63 AMG 4MATIC Sedan
• 2008-2010 Mercedes-Benz R 280 Sedan
• 2008-2010 Mercedes-Benz R 280 CDI Sedan
• 2008-2010 Mercedes-Benz R 350 Sedan
• 2008-2010 Mercedes-Benz R 500 4MATIC Sedan
• 2006-2009 Mercedes-Benz GL 320 CDI 4MATIC SUV
• 2006-2009 Mercedes-Benz GL 420 CDI 4MATIC SUV
• 2006-2009 Mercedes-Benz GL 450 4MATIC SUV
• 2006-2009 Mercedes-Benz GL 500 4MATIC SUV

There may exist other applications of this transmission non included in this list.

Source: https://www.youcanic.com/vehicle/mercedes-benz-7-speed-transmission-fluid-filter-change-instructions

Posted by: michaelquithethand.blogspot.com

Share this post